Ss-cycle Super E and G Series Shorty Performance Carburetor Manuel d'utilisateur

!" !IMPORTANT NOTICE:Statements in this instruction sheet preceded by the following words are of special signi cance.WARNINGMeans there is the po

!10!adjusted too tightly, valves may not seat properly, and the loss of compression may prevent the engine from starting. 6- Improper idle

!11!!!"#$%&'(*5( 1- Start engine and run until slightly warm (approximately 1 to 2 minutes). 2- Turn RPM adjustment screw

!12!normal riding conditions. The intermediate system controls fuel delivery from just off idle to approximately 2500-3000 rpm or 55 to 60 m

!13!or horsepower. d- Continue procedure until mph/horsepower falls off. e- Decrease or lean main jet size by .002" to gain best rpm and mph. W

!14! 6- No air cleaner used or air cleaner used is brand other than S&S. Some air cleaners restrict air flow so that carb cannot draw air as fre

!15!• If bike is used exclusively on drag strip where engine temperatures vary, slightly richer jets may be necessary to obtain best perfor

!16! !"#$%&'(*4(• When motorcycle is not running, fuel shutoff valve should always be turned off to prevent possible leakage sho

!17!!

!18!

!19!

!2! INTRODUCTION S&S® Super E and G Shorty carburetors are butterfly type carburetors with fully adjustable idle mixture and

!20!

!3! • Gasoline is extremely flammable and explosive under certain conditions. Do not smoke around gasoline. Gasoline fumes are toxic when

!4!remaining hole on left in Picture 5. 5- Assemble fast idle mechanism as shown in Figure A. ."/%&'(0(On current backplates, t

!5! NOTE: E & G carb will not fit Sportster® models equipped with OEM style magneto due to interference between magneto and carb fuel

!6!insulatorblock. 2- 1936-’65 knucklehead and panhead big twins - Bolt carb and insulator block to intake manifold, (O-ring side of bl

!7! 6- Install Air Cleaner Backplate NOTE: Backplate screws supplied with kit have pre-applied thread locking compound on threads. If s

!8!applicable. G- Check fuel overflow hose routing. Avoid hot surfaces. H- Test throttle to be sure it opens and closes freely. Turn han

!9!1. Starting Procedure of Carb Operation S&S Super E & G carburetors do not have a conventional choke. Instead, a mixture enric